Belfast Telegraph

UK Website Of The Year

Home News UK

Heathrow plane fire started by trapped battery wires

Published 19/08/2015

The Ethiopian Airlines Boeing 787 Dreamliner caught fire due to trapped battery wires, according to the report
The Ethiopian Airlines Boeing 787 Dreamliner caught fire due to trapped battery wires, according to the report

A blaze on a plane at Heathrow was triggered by trapped battery wires, an air accident report has revealed.

The Ethiopian Airlines-operated Boeing 787 Dreamliner caught fire while on a remote parking stand in July 2013.

Nobody was on board the plane at the time of the incident and there were no injuries.

The fire was caused by wires for an emergency beacon's lithium-metal battery being crossed and trapped under the battery cover which probably created a short-circuit, the report from the Air Accidents Investigation Branch (AAIB) said.

This could have enabled a "rapid discharge of the battery", leading to overheating and the release of smoke, fire and flammable electrolyte.

Investigators found that the trapped wires broke the battery seal, which allowed flames, hot gas and battery decomposition products to escape.

The beacon was installed above the ceiling of the passenger cabin towards the back of the plane.

The AAIB noted that its location made it difficult for firefighters to find the source of the blaze.

At the time of the incident the Boeing 787's information documents did not indicate there was a lithium-metal battery above the ceiling panels.

The report noted: "In the event of an in-flight ELT battery fire, fighting the ELT fire and any subsequent structural fire would be challenging for cabin crew due to the inaccessible location of the ELT in the cabin."

The investigators made a number of safety recommendations, including that the US-based Federal Aviation Administration (FAA) should assess the design of the beacon and its battery to determine whether it has an acceptable level of circuit protection to mitigate against short-circuits.

The other directions included the FAA reviewing the safety of aircraft equipment powered by lithium-metal batteries to check the level of circuit protection and make sure they comply with precautions for venting toxic gas.

Continuous production difficulties had already plagued the Dreamliner before this fire.

It should have entered passenger service in 2008 but it was not until October 2011 that the first commercial flight was operated by Japanese carrier All Nippon Airways.

Dreamliner jets were grounded worldwide in January 2013 because of problems with lithium-ion batteries that overheated or caught fire. Flights resumed four months later after a revamped battery system was installed in the planes.

Your Comments

COMMENT RULES: Comments that are judged to be defamatory, abusive or in bad taste are not acceptable and contributors who consistently fall below certain criteria will be permanently blacklisted. The moderator will not enter into debate with individual contributors and the moderator’s decision is final. It is Belfast Telegraph policy to close comments on court cases, tribunals and active legal investigations. We may also close comments on articles which are being targeted for abuse. Problems with commenting? customercare@belfasttelegraph.co.uk

Read More

From Belfast Telegraph